TY - THES A1 - Hiltensperger, Georg T1 - 4-Chinolon-3-carboxamide: Entwicklung neuer Wirkstoffe zur Behandlung der afrikanischen Schlafkrankheit T1 - 4-Quinolone-3-carboxamides: Development of new potential drugs for treatment of sleeping sickness N2 - Die humane afrikanische Trypanosomiasis (Schlafkrankheit, HAT) wird durch die Parasiten Trypanosoma brucei rhodesiense und Trypanosoma brucei gambiense ausgelöst und führt unbehandelt zum Tod. Wegen begrenzter Therapiemöglichkeiten sowie vernachlässigter Kontrollprogramme ist HAT eine gegenwärtige Bedrohung, was die Suche nach neuen Wirkstoffen notwendig macht. Ausgangspunkt für die Leitstrukturfindung war das 7-Amino-4-chinolon-3-carboxamid IV mit einem IC50-Wert (T. b. brucei) von 1.2 µM. Die 4-Chinolon-3-carboxamid-Grundstrukturen wurden unter Verwendung der Gould-Jacobs- (1-Alkyl-Derivate) bzw. der Grohe-Heitzer-Synthese (1-Aryl-Derivate) aufgebaut und anhand strukturierter Variation der Substituenten in Pos. 1, 3 und 7 die für die antitrypanosomale Wirksamkeit essenziellen Strukturelemente identifiziert: Pos.1: Die Alkylkettenverlängerung von Ethyl zu n-Butyl bewirkte eine stetige Aktivitätssteigerung, welche auch einem Aryl-Rest in dieser Position überlegen war. Pos.3: Benzylamide mit HBD-Funktionen führten zur Aktivitätsabnahme, während HBA-Funktionen und unsubstituierte Reste zur Steigerung der Wirksamkeit, teilweise in den nanomolaren Konzentrationsbereich, beitrugen. Pos.7: Neben cyclischen sek. Aminen wurden auch aliphatische prim. Amine via konventioneller oder Mikrowellen-unterstützter SNAr eingeführt. Dabei zeigten sich die sek. Amine mit einer antitrypanosomalen Aktivität im teilweise submikromolaren Bereich den acyclischen Aminen deutlich überlegen. Vor allem der Morpholin-Rest bewirkte eine sprunghafte Wirksamkeitsverbesserung. Durch Kombination der Einzelresultate konnte schließlich die den Lipinski’s „Rule of 5“ entsprechende Leitstruktur 33 mit vielversprechender antitrypanosomaler Wirksamkeit (IC50 (T. b. brucei) = 47 nM, IC50 (T. b. rhodesiense) = 9 nM) und geringer Zytotoxizität erhalten werden (SI = 19000). Erste Untersuchungen zur Identifikation des Targets der 4-Chinolon-3-carboxamide ergaben folgende Erkenntnisse: Fluoreszenzmikroskopieuntersuchungen zeigten eine deutliche Veränderung der Morphologie des Mitochondriums bei behandelten BSF-T. b. brucei-Zellen. Anhand einer Zellzyklus-Analyse wurde die Beeinträchtigung der Segregation des Kinetoplasten beobachtet, was zu einem Segregationsdefekt führte. Die Topoisomerase (TbTopoIImt) wurde durch ein „Knockdown“-Experiment als Haupt-Target ausgeschlossen. Trotz der bemerkenswerten biologischen Aktivität war eine In-vivo-Untersuchung der Leitstruktur wegen zu geringer Wasserlöslichkeit nicht möglich, welche auf eine hochgeordnete Schichtgitterstruktur zurückzuführen war. Da die Löslichkeit im Wesentlichen eine Funktion der Lipophilie und der intermolekularen Wechselwirkungen ist, wurden zur Verbesserung der Wasserlöslichkeit pharmazeutisch-technische Methoden angewandt sowie chemische Strukturmodifikationen vorgenommen: Es wurde eine Lipid-basierte, selbstemulgierende Formulierung entwickelt. Durch Ausbildung stabiler Emulsionen war 33 bis zu einer Konzentration von 10 mg/ml im Wässrigen löslich und somit für die In-vivo-Untersuchung zugänglich. Nach 4-tägiger peroraler Behandlung von NMRI-Mäusen mit einer wässrigen 1:1-Verdünnung der Formulierung konnte keine In-vivo-Aktivität festgestellt werden. Die Sprühtrocknung von 33 resultierte in amorpher Modifikation, welche in Gegenwart von PVP bzw. Eudragit®L100 stabilisiert wurde. Beide Partikel ermöglichten die Übersättigung von 33 im Wässrigen, was im Fall der Eudragit®L100-Partikel zu 200-facher Löslichkeitssteigerung gegenüber der kristallinen Wirkstoffmodifikation führte und somit die In-vivo-Untersuchung ermöglichte. Zusammen mit ersten Metabolismus-Untersuchungen von 33, welche die Berechnung einer Abbau-Kinetik bzw. Clearance ermöglichte, konnte mittels der Software Simcyp® ein Plasmakonzentrationsprofil der Verbindung 33 (Eudragit®L100-Partikel) erstellt werden. Basierend auf diesem Studiendesign wurde die In-vivo-Untersuchung von 33 an mit T. b. rhodesiense infizierten Mäusen durchgeführt und zeigte nach 8-tägiger Behandlung einen deutlichen Rückgang der Parasitämie. Im Fokus der chemischen Strukturmodifikation stand das Einführen polarer und ionisierbarer Strukturelemente, um 4-Chinolon-3-carboxamid-Derivate mit erhöhter Hydrophilie (logP 1 - 3) bzw. Salz- und Co-Kristall-Strukturen zu erhalten. Sämtliche Strukturvariationen trugen zur Verbesserung der Wasserlöslichkeit und der „drug-like“ Eigenschaften im Vergleich zu Verbindung 33 bei, waren allerdings von Aktivitätsverlusten gegenüber T. b. brucei begleitet. Anhand der „ligand efficiency“- und „lipophilic ligand efficiency“-Analyse wurden schließlich die vielversprechendsten Derivate (94 und 96) für die weitere Untersuchung ausgewählt. Mit IC50 (T. b. rhodesiense)-Werten von 4 nM (94) und 33 nM (96) und geringer Zytotoxizität wurden Selektivitätsindizes bis zu 25000 gefunden, welche jene von 33 übertrafen. Aufgrund einer Löslichkeit im millimolaren Bereich, einer moderaten Membranpermeabilität und einer Plasmastabilität von > 2 h können die Verbindungen 94 und 96 somit als erste Wirkstoffkandidaten angesehen werden. Die vollständige physiko-chemische Charakterisierung wurde mittels eines Sirius-T3-Titrationssystems durchgeführt. Unter Verwendung dieser Parameter wurden für die Derivate 94 und 96 je zwei Plasmakonzentrationsprofile mit der Software Simcyp® simuliert. Basierend auf diesem Studiendesign wurde jeweils die hohe Dosis beider Derivate im Mausmodel (T. b. rhodesiense) untersucht. Während nach 5-tägiger Behandlung mit 94 und 96 bei sämtlichen Tiere keine Parasiten mehr nachweisbar waren, wurde ein leichter Rückfall in beiden Versuchsgruppen an Tag 8 beobachtet. Gegenwärtig wird die Behandlung mit beiden Derivaten fortgesetzt. N2 - The human African trypanosomiasis (HAT, sleeping sickness) is caused by the human pathogenic subspecies Trypanosoma brucei gambiense and Trypanosoma brucei rhodesiense which are transmitted by the the bite of the tsetse fly. Without medical treatment patients fall into coma and finally die. Due to limited therapeutic options and neglected surveillance programs HAT is a current threat and makes the search for new easy accessible active compounds inescapable. The lead identification step was based on the 7-amino-4-quinolone-3-carboxamide-derivative IV showing an IC50 value of 1.2 µM against T. b. brucei. Thus, the 4-quinolone-motif was build up by either using the Gould-Jacobs-(1-alkyl-4-quinolone-derivatives) or the Grohe-Heitzer-procedure (1-aryl-4-quinolone-derivatives) followed by SAR (substituents in pos. 1, 3 and 7) to identify essential structural elements: pos.1: Prolongation of the aliphatic chain from ethyl to n-butyl led to increased antitrypanosomal activity which also surpassed the aromatic substituent. pos.3: Benzylamides with HBD-functions decreased the activity, while HBA-functions and unsubstituted benzylamides increased the antitrypanosomal potency, partially to submicromolar concentration range. pos.7: Cyclic sec. and aliphatic prim. amines were introduced in pos. 7 by conventional and microwave-assisted SNAr. In comparison, sec. amines showed higher activity, especially a morpholine residue led to an strong rise in potency. The SAR analysis on the one hand revealed lead structure 33 with promising antitrypanosomal activity (IC50 (T. b. brucei) = 47 nM, IC50 (T. b. rhodesiense) = 9 nM), drug-like properties (Lipinski’s rule of five are fulfilled), and noncritical cytotoxicity (SI = 19000). On the other hand some 1-aryl-derivatives with aliphatic, prim. or sec. amine residues and increased lipophilicity (logP 4 - 5, i. e. 49) showed growing polypharmacological properties which gave new insights in the cytotoxic potential of this molecules crucial for further lead optimization steps. To identify the target of 4-quinoline-3-carboxamide-derivatives first investigations were accomplished: Fluorescence microscopy based screening revealed significant change in the morphology of the mitochondrium for treated BSF-T. b. brucei cells. Interference of kinetoplast segregation was observed in a cell cycle analysis which resulted in a segregation defect. By means of knockdown-experiments the topoisomerase (TbTopoIImt) was excluded as main target for 4-quinolone-3-carboxamide-derivatives. Fluorescence dye labeling of 33 did not reveal further information about the target. Despite promising potency of 33, in-vivo-investigation failed due to very low water solubility caused by a highly ordered layer lattice crystal structure. Since solubility is a function of lipophilicity and intermolecular interactions, approaches from the fields of pharmaceutics and chemical structure modifications were used to overcome the problem: A lipid-based, self-emulsifying formulation was developed (SEDDS). The formation of stable emulsions enabled a drug concentration in aqueous solution of 10 mg/ml. Thus, the formulation was selected for in vivo investigation of 33 with T. b. rhodesiense infected NMRI mice. Unfortunately, the daily peroral application of a 1:1 dilution with a drug concentration of 5 mg/ml did not show any activity after four days of treatment. Spray drying of 33 in the presence of PVP and Eudragit®L100 respectively, resulted in amorphous modification confirmed by means of XRPD (ASDD). Both ASDDs enabled the supersaturation of 33 in aqueous media which in case of Eudragit®L100-ASDD contributed to a 200 fold enhanced solubility compared to the crystalline modification. Based on these results (Eudragit®L100-particle) a pharmacokinetic profile was simulated by means of the software Simcyp® (version 12.0.79.0) using a dose of 0.20 µmol/250 µl/12 h over a period of 4 d and a hepatic clearance value calculated from metabolic degradation data of compound 33. Evaluation of in vivo efficacy of 33 (ASDD-Eudragit®L100) in T. b. rhodesiense infected NMRI mice using the Simcyp® simulation revealed significant reduction of parasitaemia after 8 days of treatment. Thus, in vivo investigation is still ongoing. The main focus of the chemical modification approach was the introduction of polar and ionizable structural elements in order to decrease lipophilicity (logP 1 - 3) and to achieve 4-quinolone-3-carboxamide derivatives as salts or co-crystals. The obtained derivatives showed improved water solubility and better drug-like properties compared to 33, associated with less antitrypanosomal activity against T. b. brucei. According to ligand efficiency and lipophilic ligand efficiency analysis two promising compounds (94 and 96) were selected for further investigations. Both compounds showed IC50 values against T. b. rhodesiense in the low nanomolar concentration range (94: 4 nM, 96: 33 nM) and low in vitro cytotoxicity resulting in selectivity indices up to 25000 surpassing those of 33. Due to aqueous solubility in the millimolar range, moderate membrane permeability (Caco-2-assay) and plasma stability of > 2 h (stability-assay), both compounds were considered as potential drug candidates which were subjected to a complete physico-chemical characterization (pKa, logP, intrinsic solubility) by means of the Sirius-T3-instrument. Subsequently, these parameters were used to simulate two pharmacokinetic profiles (Simcyp®) for each compound (low dose: 0.20 µmol/250 µl/12 h, high dose: 1.00 µM/250 µl/12 h). Based on these simulations the in vivo investigations of 94 and 96 (high dose) revealed significant reduction of parasitaemia after 5 days of treatment but in both cases relapse was observed on day 8. Nevertheless in vivo investigations of 94 and 96 are currently ongoing. KW - Trypanosomiase KW - Chinolonderivate <2-> KW - Arzneimittelforschung KW - Struktur-Aktivitäts-Beziehung KW - Trypanosomen KW - Leitstrukturoptimierung KW - Löslichkeitsverbesserung KW - trypanosomiasis KW - 4-quinolone-derivatives KW - SAR KW - lead optimization KW - Schlafkrankheit KW - Mikroemulsion KW - Struktur-Aktivitäts-Beziehung Y1 - 2013 U6 - http://nbn-resolving.de/urn/resolver.pl?urn:nbn:de:bvb:20-opus-83416 ER - TY - THES A1 - Heydt, Silke T1 - Synthese von Nanopartikeln und der Einfluss ihrer Primärpartikelgröße auf die Fließregulierung von idealen und nicht-idealen Schüttgütern T1 - Synthesis of nanoparticles and the influence of their primary particle size on the flow regulation of ideal and non-ideal bulk materials N2 - Die Fließfähigkeit eines pharmazeutischen Schüttguts spielt insbesondere bei der Herstellung von volumendosierten Arzneiformen, wie beispielsweise Tabletten, eine große Rolle. Häufig kommen deshalb sogenannte Fließregulierungsmittel zum Einsatz, um eine ausreichende Fließfähigkeit zu gewährleisten. Der Prozess der Fließregulierung kann mit einer Abnahme der van der Waals Kräfte zwischen den einzelnen Schüttgutpartikeln beschrieben werden. Diese Reduktion der Haftkraft beruht auf der Anlagerung von Adsorbaten des Fließregulierungsmittels an die Oberfläche der Trägerpartikel. Im Rahmen der Arbeit sollten sowohl die Einflussfaktoren des Schüttguts als auch die des Fließregulierungsmittels auf den Prozess der Fließregulierung geprüft werden. Es wurde gezeigt, dass die Morphologie eines Schüttguts großen Einfluss auf den Prozess der Fließregulierung besitzt. Je glatter die Oberfläche eines Schüttguts ist, desto weniger Fließregulierungsmittel wird ungenutzt eingelagert. Es steht demzufolge mehr Fließregulierungsmittel als Abstandshalter zwischen den einzelnen Schüttgutpartikeln zur Verfügung, was wiederum zu einer Reduktion der van der Waals Kräfte und somit zur Fließverbesserung führt. Ein weiterer Schwerpunkt lag auf der Beurteilung des Einflusses der Primärpartikelgröße eines Fließregulierungsmittels auf seine fließregulierende Potenz. Hierzu wurden Kieselsäurenanopartikel synthetisiert, die sich lediglich in ihren Primärpartikelgrößen unterscheiden. Mit Hilfe des Sol-Gel-Prozesses innerhalb einer Mikroemulsion wurden prozesssicher diskrete, sphärische und einheitliche Kieselsäurenanopartikel in einem Größenbereich von 8 nm bis 100 nm erhalten. Um den Einfluss der Primärpartikelgröße zu prüfen, wurden die Schüttgüter Maisstärke und Lactose mit den synthetisierten Kieselsäuren versetzt und in einem Turbula-Mischer gemischt. Die Beurteilung der Potenz der Fließregulierungsmittel in Kombination mit dem jeweiligen Schüttgut erfolgte mittels Messungen am Zugspannungstester. Für beide Schüttgüter wurde eine eindeutige Korrelation zwischen der Primärpartikelgröße und der Potenz des Fließregulierungsmittels festgestellt, wobei je nach Schüttgutmorphologie unterschiedliche Ergebnisse für die optimale Primärpartikelgröße des Fließregulierungsmittels erhalten wurden. Die Auswahl eines Fließregulierungsmittels sollte demnach unter Beachtung seiner Primärpartikelgröße in Anpassung an die Schüttgutbeschaffenheit erfolgen. Somit kann der Fließregulierungsprozess zukünftig systematischer gestaltet werden. N2 - The flowability of a pharmaceutical powder plays a major role, especially in the production of volume-dosed dosage forms like tablets. Therefore, often so called flow regulators are used to ensure sufficient fluidity. The process of flow regulation can be described by a decrease of van der Waals forces between individual bulk particles. This reduction of adhesion strength is due to the addition of adsorbates of the flow control agent to the surface of the carrier particles. In the context of this work the influence factors of the bulk material as well as the flow control agent on the process of flow regulation should be examined. It was shown that the morphology of a bulk material has great influence on the process of flow regulation. The smoother the surface of a bulk material, the less flow-regulator is stored unused. Therefore, more flow control agent is available that acts as a spacer between the bulk particles leading to a reduction of the van der Waals forces and an improvement of the flowability. Another focus was on assessing the influence of the primary particle size of a flow control agent on its flow regulating potency. For this purpose, silica nanoparticles were synthesized, which differ only in their primary particle sizes. Using the sol-gel process within a micro-emulsion it was possible to produce reliably discrete, spherical and uniform silica nanoparticles in a size range of 8 to 100 nm. To examine the influence of the primary particle size, the synthesized silicas were added to corn starch and lactose and then mixed in a turbula mixer. The evaluation of the potency of the flow-regulating agents in combination with the respective bulk material was performed by measurements with a tensile strength tester. For both bulk materials a clear correlation between the primary particle size and the potency of a flow regulating agent was found. Different results for an optimal primary particle size of the flow control agent were obtained depending on the bulk morphology. Therefore, the selection of a flow control agent should be made in accordance with its primary particle size depending on the bulk composition. Thus, the flow-regulating process should be more systematically in the future. KW - Nanopartikel KW - Fließverhalten KW - Pulver KW - Schüttgut KW - Mikroemulsion KW - Zugspannung KW - Fließregulierung KW - Nanopartikelsynthese KW - flow regulation KW - microemulsion KW - nanoparticle synthesis Y1 - 2011 U6 - http://nbn-resolving.de/urn/resolver.pl?urn:nbn:de:bvb:20-opus-67489 ER -